Differences
This shows you the differences between two versions of the page.
Both sides previous revision Previous revision Next revision | Previous revision | ||
articles:changing_manual_transmission_fluid_on_a_190e [2020/11/09 08:45] – [Edit - Panel] john5788 | articles:changing_manual_transmission_fluid_on_a_190e [2020/11/10 08:58] (current) – [Procedure] john5788 | ||
---|---|---|---|
Line 42: | Line 42: | ||
</ | </ | ||
+ | < | ||
+ | <col sm=" | ||
<panel type=" | <panel type=" | ||
^ Transmission Type ^^ Capacity (L) ^ | ^ Transmission Type ^^ Capacity (L) ^ | ||
Line 52: | Line 54: | ||
| ::: | 717.45 | 1.7 | | | ::: | 717.45 | 1.7 | | ||
</ | </ | ||
+ | </ | ||
+ | </ | ||
+ | ===== Tools needed ===== | ||
+ | < | ||
+ | <col sm=" | ||
+ | * Method to lift vehicle | ||
+ | * Drain pan | ||
+ | * Hazet oil service wrench, part number 117 589 02 07 00. 14mm hex, 13mm box end. Or a 14mm hex tool short enough to fit in the transmission tunnel | ||
+ | * Fluid transfer pump | ||
+ | </ | ||
+ | <col sm=" | ||
+ | < | ||
+ | {{ articles: | ||
+ | < | ||
+ | </ | ||
+ | </ | ||
+ | <col sm=" | ||
+ | < | ||
+ | {{ articles: | ||
+ | < | ||
+ | </ | ||
+ | </ | ||
+ | </ | ||
+ | |||
+ | ===== Procedure ===== | ||
+ | |||
+ | |||
+ | |||
+ | |||
+ | < | ||
+ | <col sm=" | ||
+ | - Lift vehicle such that vehicle is level in the air | ||
+ | - Remove oil filler plug first, pay attention as to not lose the metal seal ring. | ||
+ | - Perform this item first to make sure there is a method for refilling the transmission with fluid | ||
+ | - Remove oil drain plug, pay attention as to not lose the metal seal ring | ||
+ | - Once fluid is completely drained, clean drain plug, and reinstall with max torque of 60 Nm | ||
+ | - Using the fluid transfer pump, fill the transmission fluid until it overflows from the filler hole | ||
+ | - Reinstall oil filler plug | ||
+ | - Lower the vehicle, check for leaks | ||
+ | </ | ||
+ | <col sm=" | ||
+ | < | ||
+ | <col sm=" | ||
+ | < | ||
+ | {{ articles: | ||
+ | < | ||
+ | </ | ||
+ | </ | ||
+ | <col sm=" | ||
+ | < | ||
+ | {{ articles: | ||
+ | < | ||
+ | </ | ||
+ | </ | ||
+ | <col sm=" | ||
+ | < | ||
+ | {{ articles: | ||
+ | < | ||
+ | </ | ||
+ | </ | ||
+ | </ | ||
+ | </ | ||
+ | </ |