Differences

This shows you the differences between two versions of the page.

--- articles:replacing_190e_steering_gearbox [2020/12/03 08:21] – [Steering gearbox removal] john5788
+++ articles:replacing_190e_steering_gearbox [2020/12/03 08:36] – [Installation] john5788
@@ Line 126: / Line 126: @@
 </grid>
 ==== Installation ====
+  - Install upper power steering hose with 19mm nut onto the replacement steering gearbox
+  - Install pitman arm (this can be deferred to after the gearbox has been mounted in the car for easier gearbox installation)
+    - Use centering mark to align and install
+    - Tighten down at the same depth as previously measured
+    - Install snap ring
+  - Install steering coupler to steering shaft
+    - Note the flat end on the steering shaft when installing the new coupler. This is where the bolt runs through
+  - Install steering gearbox to coupler, do not turn steering wheel to install bolt yet
+  - Install the 3 frame bolts in wheel well
+  - Tighten power steering hoses
+    - 17mm hose nut
+    - Hose clamp
+  - Install tie rod and drag link
+    - Use new self locking hex nuts
+  - Turn steering wheel and install other 6mm coupler bolt
+  - Install power steering filter in reservoir
+  - Fill power steering reservoir to capacity
+    - Steering may need to be fully rotated a few times for correct fill
+\\
+<grid>
+<col sm="3">
+<thumbnail>
+{{ articles:19mmsteeringhose.jpg?300 }}
+<caption>19mm hose on steering gearbox</caption>
+</thumbnail>
+</col>
+<col sm="3">
+<thumbnail>
+{{ articles:pitmanarmalignment.jpg?300 }}
+<caption>Pitman arm centering mark</caption>
+</thumbnail>
+</col>
+<col sm="3">
+<thumbnail>
+{{ articles:steeringshaftflatspot.jpg?300 }}
+<caption>Steering shaft</caption>
+</thumbnail>
+</col>
+<col sm="3">
+<thumbnail>
+{{ articles:steeringcouplerinstalled.jpg?300 }}
+<caption>Steering coupler installed</caption>
+</thumbnail>
+</col>
+<col sm="3">
+<thumbnail>
+{{ articles:steeringgearboxinstalledtocoupler.jpg?300 }}
+<caption>Steering gearbox installed onto coupler</caption>
+</thumbnail>
+</col>
+<col sm="3">
+<thumbnail>
+{{ articles:0004662104.jpg?300 }}
+<caption>Power steering filter</caption>
+</thumbnail>
+</col>
+</grid>