Differences
This shows you the differences between two versions of the page.
| Both sides previous revision Previous revision Next revision | Previous revision | ||
| articles:replacing_190e_steering_gearbox [2020/12/03 08:21] – [Steering gearbox removal] john5788 | articles:replacing_190e_steering_gearbox [2020/12/03 08:36] (current) – [Steering gearbox removal] john5788 | ||
|---|---|---|---|
| Line 80: | Line 80: | ||
| - Use gear puller if necessary | - Use gear puller if necessary | ||
| - Take note on where the pitman arm is mounted on the output shaft. This affects front toe settings. | - Take note on where the pitman arm is mounted on the output shaft. This affects front toe settings. | ||
| + | |||
| + | \\ | ||
| < | < | ||
| Line 126: | Line 128: | ||
| </ | </ | ||
| ==== Installation ==== | ==== Installation ==== | ||
| + | |||
| + | - Install upper power steering hose with 19mm nut onto the replacement steering gearbox | ||
| + | - Install pitman arm (this can be deferred to after the gearbox has been mounted in the car for easier gearbox installation) | ||
| + | - Use centering mark to align and install | ||
| + | - Tighten down at the same depth as previously measured | ||
| + | - Install snap ring | ||
| + | - Install steering coupler to steering shaft | ||
| + | - Note the flat end on the steering shaft when installing the new coupler. This is where the bolt runs through | ||
| + | - Install steering gearbox to coupler, do not turn steering wheel to install bolt yet | ||
| + | - Install the 3 frame bolts in wheel well | ||
| + | - Tighten power steering hoses | ||
| + | - 17mm hose nut | ||
| + | - Hose clamp | ||
| + | - Install tie rod and drag link | ||
| + | - Use new self locking hex nuts | ||
| + | - Turn steering wheel and install other 6mm coupler bolt | ||
| + | - Install power steering filter in reservoir | ||
| + | - Fill power steering reservoir to capacity | ||
| + | - Steering may need to be fully rotated a few times for correct fill | ||
| + | |||
| + | \\ | ||
| + | |||
| + | < | ||
| + | <col sm=" | ||
| + | < | ||
| + | {{ articles: | ||
| + | < | ||
| + | </ | ||
| + | </ | ||
| + | <col sm=" | ||
| + | < | ||
| + | {{ articles: | ||
| + | < | ||
| + | </ | ||
| + | </ | ||
| + | <col sm=" | ||
| + | < | ||
| + | {{ articles: | ||
| + | < | ||
| + | </ | ||
| + | </ | ||
| + | <col sm=" | ||
| + | < | ||
| + | {{ articles: | ||
| + | < | ||
| + | </ | ||
| + | </ | ||
| + | <col sm=" | ||
| + | < | ||
| + | {{ articles: | ||
| + | < | ||
| + | </ | ||
| + | </ | ||
| + | <col sm=" | ||
| + | < | ||
| + | {{ articles: | ||
| + | < | ||
| + | </ | ||
| + | </ | ||
| + | </ | ||